Admin Table of Contents
What type of fluid goes in a T5 transmission?
DexronÒ II automatic transmission fluid
Most T5 transmission models use DexronÒ II automatic transmission fluid.
What fluid goes in a ZF 5 speed?
The ZF 5 speed manual transmission calls for 3.38 quarts (3.2 liters) of synthetic MERCON ATF (Ford part number E6AZ-19582-B) or Castrol TRANSMAX-S ATF. Yes, this manual transmission requires the use of automatic transmission fluid due to its tight design tolerances.
What is the best oil for a manual transmission?
Red Line’s GL-4 transmission lubricant is our top pick for your manual car (just make sure it meets your specs). The formulation is less slippery and low in sulfur, which makes it compatible with brass synchronizers, and it meets the requirements of 70W, 75W, 80W, SAE 30, 5W30, and 10W30 motor oil.
How do you lubricate a manual transmission?
Add your gear oil back into the gearbox using the oil pump. Fill the oil into the filler until the oil reaches the level of the filler (It will ooze back out.) replace the filler bolt once again turning it by hand for a few revolutions. then tighten it and torque it using a torque wrench.
What fluid does a Borg Warner T5 take?
All WC T5’s use ATF oil or Synthetic ATF (no other oil should be used. Redline MTL should not be used, but Redline ATF is fine. Amsoil ATF could also be used).
Can I use ATF in manual gearbox?
If you drive a vehicle with a stick shift, you might wonder if automatic transmission fluid will work in your manual transmission. You might wonder if you can use Dextron-III/Ford Mercon multipurpose automatic transmission (ATF) instead of motor oil. The answer is a qualified, “Yes.”
Is there oil in a manual transmission?
Manual transmissions use a variety of oils: regular motor oil, heavyweight hypoid gear oil or even automatic transmission fluid in some cases. Your owner’s manual will tell you what your transmission calls for.
What year did GMC start using the T-5 transmission?
GM used the T-5 in the 1982 and up S/T series pickups and small Blazers, and their Astro vans. They began installing them in 1983 in the Camaros and Firebirds.
What is the transmission fluid capacity of the T5 transmission?
The transmission fluid capacity of the T5 is 2.8 quarts. The T5 transmission was a 5 speed manual transmission that was first produced in 1980 by Borg-Warner. Some significant modifications were available beginning around 1985 as the transmission made the transition from the non-world class to the world class model.
How much fluid does a Borg-Warner T5 transmission hold?
The transmission is quite light, with reported weights being between 70 to 75 pounds. The transmission fluid capacity of the T5 is 2.8 quarts. The T5 transmission was a 5 speed manual transmission that was first produced in 1980 by Borg-Warner.
How much torque can a 5-speed manual transmission handle?
A more common application would be paired to a V6 engine. The peak torque that this 5-speed manual transmission could handle was 265 lb-ft upon introduction. This power rating was the same for the non-world class as well as the original world class T5 transmission.